Alternator low volts; Nest Step regulator bad field voltage

For Next Step Regulators including Lifeline units. Use the NS2 forum for NS2 issues.

Alternator low volts; Nest Step regulator bad field voltage

Postby SheltieJim on Fri Aug 13, 2010 8:18 am

I've got an Ample Power power monitor, a Next Step regulator, and a 3rd party alternator on my sailboat. I recently discovered that the engine would not fully charge my batteries; it would charge them to only about 12.65 volts. My first action was to measure the voltage that the alternator was putting out and, sure enough, it was putting out only about 12.65 volts. A little research on this bulletin board showed me how to check the regulator voltages. Here are those results (for each pin, I've cited the voltage with the ignition switch off, then with the switch on, then with the engine running):

House battery: 12.70, 12.79, 12.65
Parallel: 12.7 12.68, 12.65
On/Off: 0, 11.96, 12.05
Gnd: 0, 0, 0
B+: 12.71, 12.68, 12.53
Field: 5.03, 5.57*, 5.54*
Alt Gnd: 0, 0, 0
Lock: 0, 0, 0
Batt Volts: 12.71, 12.67, 12.65
T-: 0, 0, 0
T+: 0, 2.94, 2.95
ABS: 0, 8.38, 8,38
Lamp: 0, 0.30, 0

* When the ignition switch was on (both without the engine running and with it running), the voltage on the Field pin mostly showed the voltage given, but about once a second the voltage would jump very briefly to a number in the 7, 8, or 9 volt range. It happened to fast to really read the meter, though.

I suspect that the Field voltages are a strong indication that the regulator has gone bad. Should I try to have it fixed, or just purchase a replacement?

Also, does the (possibly) bad regulator have anything to do with the low voltage that I see coming from the alternator? The alternator is rated to put out at least 14 volts.

Strangly enough -- and perhaps merely coincidentally -- my bank of solar panels, nominally 16.5 volts, also seem to be putting out only 12.3 volts into a FlexCharge NC25A-12 regulator. Any suggestions on this problem?

Thanks!
Jim
SheltieJim
 
Posts: 5
Joined: Tue Aug 10, 2010 9:55 am

Re: Alternator low volts; Nest Step regulator bad field voltage

Postby Coulomb on Fri Aug 13, 2010 2:31 pm

It appears the regulator is defective - not enough field voltage. Repair is generally $170 - $200.00.

The solar panels may be charging, but with a discharged battery, may not be able to drive the voltage any higher.

Send products for repair to:

Ample Power Company, LLC.
6315 Seaview Avenue, NW
Seattle, WA 98107
Coulomb
Site Admin
 
Posts: 1174
Joined: Sat Jun 06, 2009 5:11 pm

Re: Alternator low volts; Nest Step regulator bad field voltage

Postby SheltieJim on Mon Aug 16, 2010 1:52 pm

Thanks for the response. Your answer about the solar cells proved to be correct. We're debating whether to have this regulator repaired or to purchase a new one.
SheltieJim
 
Posts: 5
Joined: Tue Aug 10, 2010 9:55 am

Re: Alternator low volts; Nest Step regulator bad field voltage

Postby Coulomb on Mon Aug 16, 2010 3:22 pm

There is a trade-in allowance for either an NS2 or SAR V3. Send an email to ruth@the usual for a quote.
Coulomb
Site Admin
 
Posts: 1174
Joined: Sat Jun 06, 2009 5:11 pm


Return to Next Step Regulators

Who is online

Users browsing this forum: No registered users and 1 guest

cron